Current issue
Online first
Archive
About the Journal
Aims and scope
Publisher and Editorial
Advertising policy
For Authors
Paper review procedures
Procedures protecting authentic authorship of papers
Paper preparation manual
Plagiarism check
Publication ethics
Reviewers
APC
Editorial and Scientific Board
Contact
Reviewers
Experimental verification of changes in the control map of a diesel engine operation due to fuel consumption
1
Mechanical Engineering, Wroclaw University of Science and Technology, Poland
2
R&D, RSH Auto-Centrum, Poland
Submission date: 2024-07-30
Final revision date: 2024-09-17
Acceptance date: 2024-10-10
Online publication date: 2024-11-06
Corresponding author
Zbigniew Jan Sroka
Mechanical Engineering, Wroclaw University of Science and Technology, wyb. Wyspianski 27, PL-50-370, Wroclaw, Poland
Mechanical Engineering, Wroclaw University of Science and Technology, wyb. Wyspianski 27, PL-50-370, Wroclaw, Poland
KEYWORDS
TOPICS
ABSTRACT
The paper describes an experiment related to the introduction of changes in the control software of a supercharged diesel engine in order to reduce fuel consumption, as a measure of useful efficiency. The map shaping the torque in the range of low and medium engine speeds was modified. The fuel dose for a specific engine speed at maximum engine load was changed and the boost pressure was increased, without exceeding the permissible values. A vehicle from the age group of 16 years - typical for the automotive market in Poland, was selected for the tests. It meets the EURO 5 standard. The experiment was carried out on a chassis dynamometer and in road traffic conditions. The average fuel consumption was obtained lower by 0.4 dm3 per 100 km than the factory assumed.
REFERENCES (30)
1.
Abdullah NR, Mamat R, Rounce P, Tsolakis A, Wyszynski ML, Xu HM. The effect of injection pressure and strategy in a Jaguar V6 diesel engine. SAE Technical Paper 2009-24-0049. 2009. https://doi.org/10.4271/2009-2....
2.
Andrych-Zalewska M. Investigation of processes in the WLTC test of a passenger car with a diesel engine. Combustion Engines. 2023;194(3):52-62. https://doi.org/10.19206/CE-16....
3.
Andrych-Zalewska M, Merkisz J, Pielecha J. The influence of the heating time of a catalyst-covered glow plug on the exhaust emissions from a diesel engine. Combustion Engines. 2021;184(1):52-56. https://doi.org/10.19206/CE-13....
4.
Andrych-Zalewska M, Chłopek Z, Merkisz J, Pielecha J. Research on the results of the WLTP procedure for a passenger vehicle. Eksploat Niezawodn. 2024:26(1):176112. http://doi.org/10.17531/ein/17....
5.
Bridjesh P, Gopal A, Mohanamurugan SM. Tuning of a conventional diesel engine into a low compression ratio diesel engine. Int J Appl Eng Res. 2015;10(5):12153-12164.
6.
Dornoff J, Rodríguez F. Euro 7: the new emission standard for light- and heavy-duty vehicles in the European Union. The International Council on Clean Transportation, ICCT. March 2024. https://theicct.org/publicatio....
8.
Fluder K, Pielecha I, Cieślik W. The impact of drive mode of a hybrid drive system on the energy flow indicators in the RDE test. Combustion Engines. 2018;175(4):18-25. https://doi.org/10.19206/CE-20....
9.
He J, Chen K, Xu J. Urban air pollution and control. Encyclopedia of Sustainable Technologies. 2017:243-257. https://doi.org/10.1016/B978-0....
10.
Hopwood P, Shalders B. Euro 7/VII – New emissions limits, the challenges and solutions. Ricardo. 2020. https://mobex.io/webinar-libra....
11.
Johannesson P, Speckert M. Guide to load analysis for durability in vehicle engineering. Wiley 2019. https://doi.org/10.1002/978111....
12.
Kuta KK, Nadimi E, Przybyła G, Żmudka Z, Adamczyk W. Ammonia CI engine aftertreatment systems design and flow simulation. Combustion Engines. 2022;190(3):3-10. https://doi.org/10.19206/CE-14....
13.
Lasocki J. The WLTC vs NEDC: a case study on the impacts of driving cycle on engine performance and fuel consumption. Int J Auto Mech Eng. 2021.18(3):9071-9081. https://journal.ump.edu.my/ija....
14.
Latarche M. Pounder's marine diesel engines and gas turbines (Tenth ed.), Butterworth-Heinemann 2021. https://doi.org/10.1016/C2017-....
15.
Lus T. Contemporary diagnostic and tuning methods for marine diesel engines. Journal of KONES PowerTran. 2007;14(4):1-8.
16.
Merkisz J, Pielecha J, Radzimirski S. Emisja zanieczyszczeń motoryzacyjnych w świetle nowych przepisów Unii Eurpejskiej (in Polish). WKŁ. Warszawa 2012.
17.
Merkisz J, Bajerlein M, Zieliński B, The impact of parameter modifications in the Diesel engine power system on the emissions of harmful compounds. Combustion Engines. 2020;180(1):36-40. https://doi.org/10.19206/CE-20....
18.
Prajwowski K. The impact of alterations in control unit software on the BMW 3.0D engine power and torque. Journal of KONES. 2015;22(3):201-206.
19.
Reliable Research. Petrol Tuning & Diesel Tuning Market,.Global Outlook and Forecast 2024-2031. Reports, Rowing Research 2024.
20.
Reksa M, Sroka ZJ. The impact of fuel properties on shape of injected fuel spray. Combustion Engines. 2013;154(3):806-810.
21.
Shahadat MMZ, Nabi MN, Akhter MS, Tushar MSHK. Combined effect of EGR and inlet air preheating on engine performance in Diesel engine. Int Ener J. 2008;9:109-116. http://www.rericjournal.ait.ac....
22.
Sroka ZJ, Dworaczyński MK. Assessment of thermodynamic cycle of internal combustion engine in terms of rightsizing. Combustion Engines. 2019;178(3):182-186. https://doi.org/10.19206/CE-20....
23.
Tan X-G, Sang H-L, Qiu T, Fan Z-Q, Yin W-H. The impact of common rail system's control parameters on the performance of high-power diesel. Enrgy Proced. 2012;16C:2067-2072. https://doi.org/10.1016/j.egyp....
24.
Tutunea D, Dumitru I, Racila L, Otat O, Geonea I, Matei L, Rotea C. Experimental stand to evaluate engine mass air flow (MAF) sensor. The 30th SIAR International Congress of Automotive and Transport Engineering. SMAT 2019. Springer, Cham. https://doi.org/10.1007/978-3-....
25.
Twigg MV. Controlling automotive exhaust emissions: successes and underlying science. Philos T R Soc., A, 2005, 363, 1013, https://doi.org/10.1098/rsta.2....
Share
RELATED ARTICLE
| eISSN: | 2658-1442 |
| ISSN: | 2300-9896 |
The scientific journal is financed under the Agreement 185/WCN/2019/1 from the funds of the Minister of Science and Higher Education
© 2006-2024 Journal hosting platform by Bentus
We process personal data collected when visiting the website. The function of obtaining information about users and their behavior is carried out by voluntarily entered information in forms and saving cookies in end devices. Data, including cookies, are used to provide services, improve the user experience and to analyze the traffic in accordance with the Privacy policy. Data are also collected and processed by Google Analytics tool (more).
You can change cookies settings in your browser. Restricted use of cookies in the browser configuration may affect some functionalities of the website.
You can change cookies settings in your browser. Restricted use of cookies in the browser configuration may affect some functionalities of the website.
